The kitchen smoke exhaust project affects the health and working mood of kitchen staff. If there are problems in the project, it will affect the overall operation of the kitchen and cause fire in serious cases. Therefore, the problem of smoke exhaust engineering can not be ignored. So how about the cleaning of kitchen smoke exhaust project and the method of removing impurities?

廚房排煙工程的清洗

Cleaning of kitchen smoke exhaust works

廚房排煙工程處理電路問題。如果對電路不熟悉，清洗過程中很容易進水。建議盡量把可拆卸的東西拿掉。您可以在與清潔公司簽訂合同時說明這一點。

Kitchen smoke exhaust engineering deals with circuit problems. If you are not familiar with the circuit, it is easy to get water in the cleaning process. It is recommended to remove the detachable things as much as possible. You can explain this when signing a contract with the cleaning company.

廚房排煙工程除了比較大的清掃，也需要經常管理。有的企業在處理后對管道進行修復，形成的保護膜還可以防止油污容易殘留在油煙管道中。

In addition to large cleaning, the kitchen smoke exhaust project also needs regular management. Some enterprises repair the pipeline after treatment, and the formed protective film can also prevent oil stains from easily remaining in the oil fume pipeline.

商業場所的煙袋、煙袋常年處于高溫工作環境。如果油煙氣化的油脂結合劑不及時清洗，引發火災也就不足為奇了。因此，廚房排風系統需要清洗。清潔需要選擇清潔公司。清潔后，確保廚房油煙抽排工作正常。

Cigarette bags and cigarette bags in commercial places are in a high-temperature working environment all year round. It is not surprising that if the oil fume vaporized oil binder is not cleaned in time, it will cause a fire. Therefore, the kitchen exhaust system needs to be cleaned. Cleaning needs to choose a cleaning company. After cleaning, ensure that the kitchen fume exhaust works normally.

廚房排煙工程排雜質方法

Method for removing impurities in kitchen smoke exhaust project

風管與風機連接時，進風口和出風口應安裝軟接頭。軟接頭的橫截面尺寸應與風機進、排氣口的橫截面尺寸相同。軟管接頭可由帆布、人造革和其他材料制成。軟管長度不宜小于200，拉力要適當。軟管可抑制風扇的振動。

When the air duct is connected with the fan, soft joints shall be installed at the air inlet and outlet. The cross-sectional dimension of the flexible joint shall be the same as that of the air inlet and outlet of the fan. Hose joints can be made of canvas, artificial leather and other materials. The hose length should not be less than 200, and the tension should be appropriate. The hose suppresses the vibration of the fan.

風管連接除塵設備和加熱設備時，設備安裝完畢后，應按理論勘察圖暫停預制安裝。

When the air duct is connected with dust removal equipment and heating equipment, the prefabrication and installation shall be suspended according to the theoretical survey drawing after the equipment installation.

廚房安裝排煙管時，應在風管預制時打開進出風口。如果在安裝結束時需要打開風管，其接頭應緊密。

When installing the smoke exhaust pipe in the kitchen, the air inlet and outlet shall be opened during the prefabrication of the air pipe. If the air duct needs to be opened at the end of installation, its joint shall be tight.

輸送冷凝水或含水量較大的氣體時，水平管道應傾斜并在低點與排水管相連。安裝時，風管底部不應有縱向接縫，底部接縫應臨時密封。

When transporting condensate or gas with large water content, the horizontal pipeline shall be inclined and connected with the drainage pipe at the low point. During installation, there shall be no longitudinal joint at the bottom of the air duct, and the bottom joint shall be temporarily sealed.

輸送易燃易爆氣體的鋼板風管，在風管的連接法蘭處應安裝跨接線，并與靜電接地網相連接。

For steel plate air duct conveying flammable and explosive gases, jumper wires shall be installed at the connecting flange of the air duct and connected with the electrostatic grounding grid.

水平風管高度在4m以上時，安裝人員應系好帶。腳手架或移動支架上的跳板應固定好，跳板的寬度應符合規定。安裝在腳手架上的人員應隨身攜帶袋子，以防物體或電鉆掉落傷人。

When the height of the horizontal air duct is more than 4m, the installer shall fasten the safety belt. The springboard on the scaffold or mobile support shall be fixed, and the width of the springboard shall comply with the safety regulations. The personnel installed on the scaffold shall carry bags with them to prevent objects or electric drills from falling and hurting people.

雙臂架支架在風管內就位后，橫臂應平直，臂架不得改變，雙臂架受力均勻。

After the double arm support is in place in the air duct, the cross arm shall be straight, the boom shall not be changed, and the double arm support shall be stressed evenly.

濟南廚房排煙排氣管每三個月清洗一次，既能保證正常運行，又能延長通風管的使用壽命。

The smoke exhaust pipe of Jinan kitchen is cleaned every three months, which can not only ensure the normal operation, but also prolong the service life of the ventilation pipe.

以上就是廚房排煙工程的清洗以及排雜質方法的注意事項，希望對大家有所幫助。如果您想了解更多知識，歡迎收藏并關注我們的網站動態m.lcyucheng.com。

The above are the precautions for the cleaning of kitchen smoke exhaust project and the method of removing impurities. I hope it will be helpful to you. If you want to know more, please collect and pay attention to our website. m.lcyucheng.com com。